Stove glass
Cracked or broken glass is replaced with ceramic glass cut for the stove along with a new glass gasket.
Fireplace Service
Wood Stove Repair Stroudsburg, PA
A wood stove that smokes into the room, burns through wood too fast or will not hold a fire usually has a worn gasket, a damaged baffle or a draft problem, and a technician in Stroudsburg can repair it. Dial (272) 271-1491 to reach a local technician who repairs wood stoves.
The whole point of a closed stove is controlled air, which is why worn seals cause so many problems. Too much air from leaky seals means a fire that roars through fuel, and too little draft means smoke, sooty glass and a fire that sulks.
Inside the firebox, the parts that take the most heat wear out first. Cracked firebrick exposes the steel, a warped baffle sends smoke up the flue unburned, and a worn catalytic combustor stops cleaning the exhaust. Parts are usually ordered by model, so look for the label on the back or side of the stove.
Signs of overfiring deserve attention before the next fire. A glowing red stovepipe or stove top, warped plates or cracked castings mean the stove has run hotter than it was built for. Stop using an overfired stove until it is inspected, and treat a chimney fire as an emergency: get everyone out and call 911.
Many wood stove repair calls in Stroudsburg also turn up a need for wood stove installation or creosote removal.
Dealing with this in Stroudsburg, PA right now? Call (272) 271-1491 and describe the problem to a chimney sweep who works in Stroudsburg.
Call nowThe process
How wood stove repair works
A stove repair starts with finding out why it misbehaves, not just swapping parts.
Ask about the fire
How the stove behaves, how fast it burns and what wood goes in all point to the cause. Wet wood alone causes many complaints.
Examine the firebox
Door and glass gaskets, latch, firebrick, baffle, air tubes and castings are checked one by one. On catalytic stoves, the combustor is checked for clogging and crumbling.
Look at the flue
Draft problems are traced through the connector pipe, damper and chimney. Sometimes the stove is fine and the flue is the fix.
Repair the stove
New gaskets, ceramic glass, firebrick, baffle boards or air tubes are installed to fit the model, following the manufacturer specifications.
Test fire
A test fire confirms the stove drafts, seals and turns down properly. Ask how often to check gaskets and firebrick going forward.
What is included
Common wood stove repairs
Combustor replacement
Worn or clogged combustors in catalytic stoves are cleaned or replaced along with its gasket.
Firebrick
Cracked, crumbling or missing firebricks are replaced to protect the steel or cast iron.
Baffles
Baffles and secondary air tubes that sag, crack or burn through are replaced to restore clean, efficient burning.
Door gaskets
Old gasket rope and cement are removed and new gaskets installed to restore control of the fire.
Related service
Wood Stove Cleaning Stroudsburg, PA
Cleaning a wood stove means more than scooping ashes, since the stovepipe, baffle area and chimney all collect creosote. Ash is vacuumed out with a sealed vacuum, the area above the baffle is cleaned, and the stovepipe and chimney are brushed. Light stage 1 soot brushes away, while sticky stage 2 and glazed stage 3 creosote can call for special tools or chemical treatments.
A Stroudsburg stove that runs daily may need sweeping more than once a season. Many sweeps recommend cleaning once about an eighth of an inch of buildup is present. Keep ashes in a lidded metal container outside, away from the house.
Local help
Wood Stove Repair Near Me
Around Stroudsburg, stove repairs pile up once the burning season is in full swing, with worn gaskets and dirty stovepipes leading the list. Homes in Stroudsburg and nearby towns like Arlington Heights, East Stroudsburg, Penn Estates and Bangor burn everything from long-seasoned hardwood to wood split that same fall, and the wetter the wood, the more creosote and sooty glass the stove produces.
For wood stove repair in Stroudsburg, PA or nearby towns like Arlington Heights, East Stroudsburg, Penn Estates and Bangor, call (272) 271-1491 to reach a chimney sweep who covers your street.
How the weather here affects chimneys around Stroudsburg
Winters here are long and cold, and the heating season usually runs from October well into April. The hardest thing on brick here is not the cold itself but the constant swing above and below freezing: rain and melting snow soak into the crown and joints, then freeze and push them apart, and each winter widens the cracks a little more. Wind driven rain from coastal storms finds any gap in flashing, too. That is why chimney cleaning in Stroudsburg is usually booked in the fall, before the first cold night.
Why call
Why not wait
Safer fires
Small chimney problems caught early usually stay small repairs.
Sweeps who know Stroudsburg
Local sweeps see the same chimney types and weather wear across Stroudsburg and nearby towns.
Clear next steps
Ask your questions before you agree to anything.
Common questions about wood stove repair
Why is my wood stove smoking into the room?
Smoke indoors means either the stove is not sealed or the chimney is not drawing well. Leaky door seals and loose stovepipe joints let it escape, and a creosote-lined flue or blocked cap makes it worse. Because smoke brings carbon monoxide with it, have it fixed before burning again and keep CO alarms in working order.
How often should wood stove gaskets be replaced?
The gasket condition, not a set number of years, decides when it gets replaced. Try closing the door on a strip of paper at several spots, and if it pulls out easily anywhere, the gasket is worn. Checking them before each heating season is a good habit.
What causes black glass on a wood stove?
Sooty glass is a sign the fire is burning too cool. A damaged glass gasket can also let in air that leaves streaks. Switching to seasoned wood is often the whole fix.
Does a wood stove chimney need cleaning every year?
An annual inspection is the standard, and sweeping is done whenever buildup is found. Stoves used daily often need sweeping at least once a year, and sometimes mid-season. Damp wood and low burns make more frequent sweeping necessary.
Can cracked wood stove glass be replaced?
Cracked stove glass can be replaced with ceramic glass cut to fit the door. Stop using the stove until it is fixed, since a crack can open up and let smoke and sparks out. Only stove-rated ceramic glass is safe in a wood stove door.
More questions? Call (272) 271-1491
Often needed together
Wood Stove Installation
Setting up a new wood stove from hearth pad to chimney cap, with stovepipe, liner or chimney sized to the stove.
Learn moreCreosote Removal
Breaking down and clearing creosote buildup of every stage before it can fuel a chimney fire.
Learn moreChimney Liner Repair
Fixing gaps, cracks and missing mortar inside the flue liner so smoke and gases stay sealed inside the flue.
Learn morePellet Stove Repair
Repair for pellet stoves that will not light, shut down or jam, with the burn pot, exhaust path and vent cleaned along the way.
Learn more
Looking for something else?
See all chimney servicesTalk to a Stroudsburg chimney sweep about wood stove repair
Call (272) 271-1491 for a local chimney sweep in Stroudsburg and nearby towns.
(272) 271-1491
Free to call. No forms to fill out.